한국재료학회지 (Korean Journal of Materials Research)

  • 제8권12호
  • /
  • Pages.1138-1145
  • /
  • 1998
  • /
  • 1225-0562(pISSN)
  • /
  • 2287-7258(eISSN)
한국재료학회 (Materials Research Society of Korea)
권호 표지

졸-겔법에 의한 강유전성 PMN 분말 및 박막의 제조와 특성

The Processing and Characterization of Sol-Gel Derived Ferroelectric PMN Powders and Thin Films

  • 황진명 (인하대학교 무기재료공학과) ;
  • 장준영 (인하대학교 무기재료공학과) ;
  • 은희태 (인하대학교 무기재료공학과)
  • 발행 : 1998.12.01
PDF 다운로드
⟨ 이전 논문 다음 논문 ⟩

초록

Ni계 경면합금인 Deloro 50의 마모거동을 15ksi와 30ksi 접촉응력하의 여러 마모조건에서 조사하였다. 상온대기중에서 Deloro 50는 15ksi 응력에서도 극심한 응착마모가 발생하는 매우 낮은 마모저항성을 보였는데 이는 fcc 결정구조를 갖는 Deloro 50 기지상의 경도와 가공경화율이 strain-induced 상변태를 이웅한 hcp 결정구조의 Stellite 6보다 낮기 때문으로 생각된다. 상온 수중에서 Deloro 50는 15ksi 응력에서 Stellite 6와 비슷한 마모저항성을 보였는데 이는 물이 미세요철간의 금속간 접촉을 억제하였기 때문으로 생각된다. 그러나, 30ksi의 높은 접촉응력에서는 상온 대기중길 같은 응착마모가 발생하는 것으로 보아, 30ksi의 높은 응력에서는 물의 응착마모 억제 효과가 없었기 때문으로 생각된다. $300^{\circ}C$ 대기중에서 Deloro 50는 30ksi의 높은 접촉응력에서도 Stellite 6보다 우수한 마모저항성을 보였는데 이는 고온에서 마모시 생성되는 복합산화물층이 효과적으로 금속간 접촉을 방해하여 응착마모를 억제하였기 때문으로 생각된다.

The sliding wear behavior of Ni-base hardfacing alloy, Deloro 50, was investigated at the contact stresses of 15ksi and 30ksi under the various wear environments. In air at room temperature, Deloro 50 showed lower wear resistance than Stellite 6 even at 15ksi due to the occurrence of severe adhesive wear. This seems to be caused by the lower hardness and work- hardening rate of Deloro 50 than those of Stellite 6. In water at room temperature, Deloro 50 showed as good wear resistance as Stellite 6 at 15ksi. It was considered to be due to that water could effectively prevent metal to metal contact through contacting asperities. However, Deloro 50 showed severe adhesive wear at 30ksi in water at room temperature. It seems to be that the water could not suppress adhesion wear at 30ksi. At $300^{\circ}C$ in air, Deloro 50 exhibited higher wear resistance than Stellite 6 even at 30ksi. It was considered that the oxide glaze layers formed on wear surface during sliding, effectively prevented direct metal-to-metal contacts.

키워드

참고문헌

  1. Am. Ceram. Soc. Bull. v.66 no.4 Preparation of Lead-Based Ferroelectric Relaxors for Capacitors T.R.Shrout;A.Halliyal
  2. Ferroelectric Thin Films v.200 Processing, Perovskite Phase Development, and Dielectric Properties for Sol-Gel Derived Pb[$(Mg_{1/3}Nb_{2/3})_{0.9}Ti{0.1}$]O₃Thin Layers L.F.Francis;D.A.Payne;E.R.Myers(ed.);A.I.Kingon(ed.)
  3. Am. Ceram. Soc. Bull. v.71 no.1 Advances in Processing of Ferroelectric Thin Film L.M.Sheppard
  4. J. Am. Ceram. Soc. v.73 no.4 The Role of Excess Magnesium Oxide or Lead Oxide in Determining the Microstructure and Properties of Lead Magnesium Niobate H.C.Whang;W.A.Schulze
  5. Mat. Res. Bull. v.20 Low Firing Dielectrics Based on Lead Magnesium Niobate M.Lejeune;J.P.Boilot
  6. J. Am. Ceram. Soc. v.69 no.12 Effect of Powder Purity and Second Phases on the Dielectric Properties of Lead Magnesium Niobate Ceramics J.Chen;A.Gorton;H.M.Chan;M.P.Harmer
  7. Jpn. J. App. Phys. v.30 no.9 Perparation of Lead-Based Perovskite Films by Sol-Gel Method and Their Properties J.Kano;T.Yogo;S.Sakka
  8. Jpn. J. App. Phys. v.28 no.6 Preparation of Pb($Mg_{1/3}Mb_{2/3}$)O₃ Thin Film by Sol-Gel Method K.Okuwada;M.Imai;K.Kauno
  9. J. Am. Ceram. Soc. v.72 no.8 Synthesis and Microstructure of Highly Oriented Lead Titanate Thin Films Prepared by a Sol-Gel Method C.Chen;D.F.Ryder,Jr.
  10. J. Mater. Sci. v.25 Sol-Gel Processing and Properties Lead Magnesium Niobate Powders and Thin Layers L.F.Francis;Y.J.Oh;D.A.Payne
  11. Mater. Res. Bull. v.17 Fabrication of Perovskite Lead Magnesium Niobate S.L.Swartz;T.R.Shrout
  12. 한국요업학회지 v.32 no.3 Pb($Zr_{1/3}Nb_{2/3})O_3-Pb(Fe_{1/2}Nb_{1/2}$)O₃계에서의 Perovskite상의 안정성 및 유전성 김정욱;최상철;이응상
  13. Better Ceramics Through Chemistry v.32 The Effect of Hydrolysis Conditions on the Structure and Growth of Silicate Polymers K.D.Keefer;C.J.Brinker(ed.);D.E.Clark(ed.);D.R.Ulrich(ed.)
  14. Phys. Rev. v.105 no.6 Infrared-Absorption Studies on Barium Titanate and Related Materials J.T.Last
  15. Mater. Res. Bull. v.25 Short-Range Order on Pb($Mg_{1/3}Mb_{2/3}$)O₃Ceramics by Raman Spectroscopy E.Husson;L.Abello;A.Morell
  16. Chemical Processing of Advanced Materials Ultrastructure Processing of Thin Crystalline Films J.D.Mackenzie;R.Xu;X.Yuhuan;L.L.Hench(ed.);J.K.West(ed.)
  17. J. Am. Ceram. Soc. v.73 no.4 The Role of Excess Magnesium Oxide or Lead Oxide in Determining the Macrostructure and Properties of Lead Magnesium Niobate Hui-Chieh Wang;Walter A.Schulze
  18. 한국요업학회지 v.26 no.5 Pb($Mg_{1/3}Mb_{2/3}$)O₃ 세라믹스의 전기적 특성 강동헌;윤기헌
  19. Soviet Phys. Solid State v.1 no.10 Dielectric Polarization of a Number of Compounds G.A.Smolenskii;A.I.Aranovaskaya
  20. J. Inor. Neucl. Chem. v.38 no.1 Double Isopropoxides of Niobium and Tantalum with Alkaline Earth Metal S.Govil;P.N.Kapoor;R.C.Mehrotra