Journal of the Korean Ceramic Society (한국세라믹학회지)

The Korean Ceramic Society (한국세라믹학회)
권호 표지

Synthesis of $BaTi_4O_9, Ba_2Ti_9O_{20}$ and $BaTi_5O_{11}$ Compounds by Coprecipitation Method and Their Electrical and Thermal Properties

공침법에 의한 $BaTi_4O_9, Ba_2Ti_9O_{20}$ 및 $BaTi_5O_{11}$화합물의 합성 및 그의 전기적, 열적 특성

  • 김종옥 (배재대학교 공과대학 무기재료공학과) ;
  • 손우창 (명지대학교 공과대학 무기재료공학과) ;
  • 전성용 (명지대학교 공과대학 무기재료공학과) ;
  • 이경희 (명지대학교 공과대학 무기재료공학과) ;
  • 이병하 (명지대학교 공과대학 무기재료공학과)
  • Published : 1994.09.01
Download PDF
⟨ Previous Next ⟩

Abstract

The three different composition of BaTi4O9, Ba2Ti9O20 and BaTi5O11 were prepared by coprecipitation process, and then the dielectric properties of these compounds were measured at low microwave frequencies. The powder showing high level of purity was synthesised by the coprecipition reaction of BaCl2 and TiCl4 where (NH4)2CO3 and NH4OH were used as a deflocculent. Followings are the result of this study: 1. The sintering temperature increased with increasing TiO2 content. 2. BaTi4O9 powder were synthesized as a single phase by this processing technique, but the resultant Ba2Ti9O20 and BaTi5O11 phase existed with Ba2Ti9O20 and BaTi5O11 phases. 3. Single phase BaTi4O9 showed high dielectric constant value of 35, high Q value of 8100.

Keywords

References

  1. 東芝レビュ一 v.32 no.88 マイクロ波誘電體セラミックス 水谷敏昭 大熊英夫外
  2. エレクトロニクセラミクス v.冬 no.24 マイクロ波セラミックコンデンアサの-考察 鋪春男
  3. 新學會技術硏究會報告 v.MW75-9 no.1 誘電體共振器を用いた同軸型アイクロ波帶域波器 脇野喜久男ほか
  4. 電氣四學會連大 v.234 誘電體デバイスと應用技術 小西良弘
  5. 電氣四學會連大 v.237 誘電體とマイクロ波フィルタ- 內侮要三
  6. 電氣四學會連大 v.235 最新のマイクロ波誘電體材料 脇野喜久男ほか
  7. Proc 1st FMA v.0-8 no.169 Dielectric and Optical Properties of the $(Sr_{1-x}Ca_x){(Li_{1/4}Nb_{3/4})_{1-y}Ti_y}O_3$ System Inchinose, N.(et. al)
  8. ibid v.F-6 no.293 Dielectric Properties of $Ba(Zn_{1/3}Ta_{2/3})O_3$ Ceramics at Microwave Frequency Kawashima;S.(et. al)
  9. Proc. IEEE. v.59 no.11 New Low-Loss High-K Temperature-Comenesated Dielectric for Microwave Applications D. J. Masse(et al)
  10. J. Am. Ceram. Soc. v.57 Phase Equilibria in the $TiO_2$-rich Region of the System BaO-TiO₂ H.M. O'Bryan(et. al)
  11. Acta Crystallogr v.25 B no.8 The Crystal Structure of $BaTi_5O_{11}$ E. Tillmanns
  12. サイエスフォラム ニコセラミック粉體ハンドブック 加藤昭夫外
  13. J. Am. Ceram. Soc. v.74 no.5 Sol-Gel Process for the Preparation of $Ba_2Ti_9O_{20}\;and\;BaTi_5O_{11}$ Hsin-chun Lu
  14. J. Kor. Seram. Soc. v.26 no.3 Reaction Mechanism on the Synthesis of BaTiO₃by Direct wet Process K.H. Lee;B.H. Lee;D.W. Kim
  15. IRE Trans MTT v.MTT-8 A Dielectric Resonator Method of Measuring Capacities in the Millmeter Range B.W. Hakki;P.D. Coleman
  16. J. Am. Ceram. Soc. v.59 no.9-10 $Ba_2Ti_9O_{20}$ as a Microwave Dielectric Resonator J.K. Plourde;D.F. Linn;H.M. O'Bryan;J. Thomson
  17. セラミック工學ハンドブック 日本セラミッツクス協會編
  18. J. Am. Ceram. Soc. v.67 no.4 Microwave Characteristics of(ZrSn)TiO₄and BaO-PbO-Nd₂O₃-TiO₂Dielectric Resonators K. Wakmo(et. al)
  19. Jpn. J. Appl. Phys. v.21 no.10 Ba$(Mg_{1/3}Ta_{2/3})$O₃Ceramics with Temperature-Stable High Dielectric Constant and Low Microwave Loss S. Nomura;K. Toyama;K. Kaneta