인삼제품(人蔘製品)의 품질안정성(品質安定性)에 관한 연구(硏究) -2. 인삼정분(人蓼精粉)과 시판다류제품(市販茶類製品)의 품질안정성(品質安定性) 비교(比較)-

Studies on Stability for the Quality of Ginseng Products -2. Comparative Study on Keeping Quality of Red Ginseng Extract Powders(RGEPs) and Commercial Dehydrated Tea Products-

유통과정(流通過程)중의 품질안정성(品質安定性) 유지(維持)가 항상 문제시되고 있는 홍삼정분(紅蓼精粉)(동결(凍結) 및 분무(噴霧))의 안정성(安定性)을 시판차류정품(市販茶類精品)과 비교(比較)하기 위하여 이들 제품(製品)의 흡습특성(吸濕特性)을 비교(比較)하였고 또 초기수분함량(初期水分含臺), 조지방함량(粗脂肪含量) 및 밀도(密度)와의 관계(關係)를 조사(調査)하여 홍삼정립(紅蓼精粒)의 안정성(安定性) 미치는 영향(影響)을 비교(比較)하였다. (1) 홍삼정분(紅蔘精粉) 및 시판차류제품(市販茶類製品)의 입도(粒度)는 100 mesh 이하였으며 동결건조제품(凍結乾燥製品)이 분무건조제품(噴霧乾燥製品)보다 입도(粒度)가 컸다. (2) 홍삼정분(紅蓼精粉)(동결(凍結) 및 분무(噴霧))이 3.85% 및 4.56% 로 초기수분함량(初期水分舍量)이 높은데 비해 커피(동결(凍結) 및 분무(噴霧))가 2.17% 및 3.52%로 낮았으며 홍삼정분(紅蔘精粉)이 커피 보다 1.3$\sim$l.8배의 높은 초기수분함량(初期水分含量)을 나타냈다. (3) 탱이나 쌍화차가 흡습율(吸濕率)이 가장 낮아 높은 안정성(安定性)을 나타냈는데 이는 탱과 쌍화차의 지방함량(脂肪含量) (4.12% 및 0.62%)이 높을 뿐만 아니라 밀도(密度)(0.89g/ml 및 0.59g/ml)도 다른 제품(製品)에 비해 훨씬 높기 때문으로 판단된다. (4) 커피의 흡습율(吸濕率)이 홍삼정분(紅參精粒)보다 컸으나 커피의 안정성(安定性)이 홍삼정분(紅蔘精紛)보다 더 높은 것은 커피의 초기수분함량(初期水分含量) (2.17${\sim}$3.52%)이 홍삼정분(紅蓼精粉) (3.85${\sim}$4.56%)보다 낮을 뿐만 아니라 커피의 지방함량(脂肪含量)(0.31${\sim}$0.38%)도 홍삼정분(紅蔘精粉)(0.12${\sim}$0.16%) 보다 훨신 높기 때문으로 판단된다. (5) 따라서 홍삼정분(紅蓼精粉)의 안정성(安定性)을 높이기 위해서는 현행 물추출방벙(抽出方法)을 용매추축(溶媒抽出)로의 전환(轉換)이나 지방피막(脂肪皮膜) 처리(處理)에 의한 흡습물성(吸濕物性)을 개선(改善)함이 바람직할 것으로 판단된다.

To compare the keeping quality of freeze and spray dried red ginseng extract powders(RGEPs) and commercial dehydrated tea products, particle sizes and initial moisture contents of these products were measured, and the relationships between crude fat contents and moisture contents and/or densities were studied. Particle sires of RGEPs and commercial dehydrated tea products were below 100 mesh, and particle sizes of freeze dried products were higher than those of spray dried products. Initial moisture contents of freeze and spray dried RGEPz were 3.587 and 4.56f, and those of frecze and spray dried coffees were 2.17% and 3.52%, respectively. Crude fat contents of tang and ssanghwa tea were 4.12% and 0.62%, and densities of tang and ssanghwa tea were 0.89 g/ml and 0.59 g/ml, respectively. Absorption rates o( tang and ssanghwa tea were the lowest among these products, it was considered because of crude fat contents of tang and ssanghwa tea were higher than these of the other products, and densities of tang and ssanghwa tea were higher than these of the other products. Notwithstanding absorption rates of RGEPs were lower than those of coffees, to maintain lower keeping quality of RGEPs than that of coffees, it was considered that HGEPs are not only lower to coffees in crude fat contents but also in densities. A sinificant relationships were found between keeping Quality and crude fat content and/or density.