DOI QR코드

DOI QR Code

Bonding of Different Mate using Common Glass in Zero Shrinkage LTCC

공통의 Glass를 이용한 LTCC 이종소재의 무수축 접한

  • 장의경 (요업(세라믹)기술원 시스템모듈사업단) ;
  • 신효순 (요업(세라믹)기술원 시스템모듈사업단) ;
  • 여동훈 (요업(세라믹)기술원 시스템모듈사업단) ;
  • 김종희 (요업(세라믹)기술원 시스템모듈사업단)
  • Published : 2006.12.01

Abstract

To improve warpage, delamination and the chemical reaction between 2 different co-fired materials, the bonding behavior with common glass was studied. As shown in the previous paper, the phenomenon of the infiltration is different with the composition of the glass. In particular, in the case of low temperature melting glass, infiltration is experimented in this study. GA-1 glass is infiltrated among $BaTiO_3$ particles below $800^{\circ}C$ and is made by glass/ceramic composite. Until the laminate is fired under $850^{\circ}C$, provskite phase is observed. Although in the case of GA-12 glass, the temperature of the glass infiltration is lower than it of GA-l glass, the perovskite phase already disappears at $800^{\circ}C$. As a result, GA-1 and GA-12 glasses are infiltrated among particles at low temperature, however, the chemical reactivity of the glass/ceramic and sintering temperature should be considered.

References

  1. 박재환, 박재관, 'LTCC 소재 및 공정 기술 개요', 세라미스트, 4권, 4호, p. 41, 2001
  2. 오영제, 정형진, '세라믹스 테이프케스팅 성형 기술', 요업기술, 12권 1호, p. 3, 1997
  3. 문제도, 'Zero shrinkage LTCC 및 embedded passive기술', 세라미스트, 8권, 3호, p. 49, 2005
  4. 최돈철, 김성욱, 고현종, 'LTCC 공정을 이용한 다중칩모듈 설계의 기초', 세라미스트, 6권, 1호, p.13, 2003
  5. Y. J. Choi, J. H. Park, W. J. Ko, J. H. Park, S. Nahm, and J. G. Park, 'Co-firing of low- and middle- permittivity dielectric tapes of fabricating low-temperature cofired ceramics', Kor. J. Mater. Res., Vol. 14, No. 10, p. 731, 2004 https://doi.org/10.3740/MRSK.2004.14.10.731
  6. Y. J. Choi, J. H. Park, S. Nahm, and J. G. Park, 'Low-temperature sintering and phase change of $BaTi_4O_9$-based ceramics middle-k LTCC dielectric compositions by glass addition', J. Kor. Ceram. Soc., Vol. 41, No. 12, p. 915, 2004 https://doi.org/10.4191/KCERS.2004.41.12.915
  7. J. H. Park, Y. J. Choi, W. J. Ko, J. H. Park, S. Nahm, and-J. G. Park, 'Low- temperature sintering and dielectric properties of $BaTiO_3$ -based ceramics for embedded capacitor of LTCC module', J. Kor. Ceram. Soc., Vol. 42, No.2, p. 81, 2005 https://doi.org/10.4191/KCERS.2005.42.2.081
  8. H. S. Shin, J. H. Wang, and J. H. Kim 'Glass infiltration in bonding of $BaTiO_3$ and $Al_2O_3$ Layers', Mater. Sci. Forum, Vol. 534-536, p. 1457, 2006
  9. M. Lahti and V. Lantto, 'Passive RF band-pass filters in a LTCC moudule made by fine-line thick-film pastes', J. Euro. Ceram. Soc., Vol. 21, p. 1997, 2001 https://doi.org/10.1016/S0955-2219(01)00159-5
  10. K. B. Shim, N. T. Cho, and S. W. Lee, 'Silver diffusion and microstructure in LTCC multilayer couplers for high frequency applications', J. Mater. Sci., Vol. 35, p. 813, 2000
  11. O. Dernovsek, A. Naeini, G. Preu, W. Wersing, M. Eberstein, and W. A schillelr, 'LTCC glass-ceramic composites for microwave application', J. Euro. Ceram. Soc., Vol. 21, p. 1693, 2001 https://doi.org/10.1016/S0955-2219(01)00096-6
  12. Y. C. Lin and J. H. Jean, 'Constrained densification kinetics of Alumina/Borosilicate glass + Alumina/Alumina sandwich structure', J. Am. Soc., Vol. 85, No. 1, p. 150, 2002 https://doi.org/10.1021/ja00896a021
  13. S. Y. Tzeng and J. H. Jean, 'Stress development during constrained sintering of Alumina/Glass/Alumina sandwich structure', J. Am. Ceram. Soc., Vol. 85, No.2, p. 335, 2002